主办：陕西省汽车工程学会
ISSN 1671-7988  CN 61-1394/TH
创刊：1976年
汽车实用技术

汽车实用技术 ›› 2025, Vol. 50 ›› Issue (1): 75-79.DOI: 10.16638/j.cnki.1671-7988.2025.001.015

• 测试试验 • 上一篇    

基于道路载荷的副车架台架试验载荷 谱编制研究

杨军   

  1. 1.江铃汽车股份有限公司 产品开发中心； 2.江西省乘用车结构设计工程研究中心
  • 发布日期:2025-01-09
  • 通讯作者: 杨军
  • 作者简介:杨军（1986－），男，硕士，工程师，研究方向为汽车结构耐久和可靠性，E-mail:13970925890@139.com

Research on Load Spectrum Compilation of the Sub-Frame Rig Test Based on the Road Load Data

YANG Jun1,2   

  1. 1.Product Development & Technical Center, Jiangling Motors Company Limited; 2.Jiangxi Engineering Research Center of Passenger Car Structure Design
  • Published:2025-01-09
  • Contact: YANG Jun1,2

PDF

摘要： 某轻型商用车在整车道路耐久测试中出现副车架开裂失效问题，针对该问题，采集控 制臂球销处的道路载荷谱，按虚拟 S-N 曲线计算球销载荷谱的伪损伤，根据 Miner 线性疲劳 损伤累积原则，计算得到球销处的全寿命损伤。选取合适的多级载荷幅值，并根据损伤等效 原则，得到各级载荷幅值的循环次数。按照损伤等效计算得到的多级载荷谱对副车架和控制 臂进行台架试验，台架试验结果复现了副车架的路试开裂问题，且失效台架失效模式、寿命 与整车路试结果有很好的关联性。后续优化后的副车架用该多级载荷谱进行台架验证通过后 同样通过了路试耐久考核。

关键词: 道路载荷谱；损伤等效；副车架；多级谱

Abstract: The sub-frame of one light commercial vehicle cracked during the road durability test, based on this problem, acquire the road load data of the ball joint of the control arm, and then calculated the pseudo-damage of the ball joint based on the virtual S-N curve. According to the Miner principle, calculated the whole life damage of the ball joint. Select the appropriate amplitude of the multi-level load spectrum, and get the cycle number of each level of load amplitude according to the principle of damage equivalence. The bench test of sub-frame and control arm is carried out based on the multi-level load spectrum that obtained by damage equivalence calculation, the result of the rig test reproduce the sub-frame crack of the road test, and the failure mode, life of the failure have a good correlation with the road test. The optimized sub-frame passes the bench test with the multi-level load spectrum, and also passes the road durability test.

Key words: road load data; damage equivalent; sub-frame; multilevel spectrum