主办：陕西省汽车工程学会
ISSN 1671-7988  CN 61-1394/TH
创刊：1976年
汽车实用技术

汽车实用技术 ›› 2021, Vol. 46 ›› Issue (16): 17-20.DOI: 10.16638/j.cnki.1671-7988.2021.016.007

• 新能源汽车 • 上一篇    下一篇

新能源车前端蒸发器结霜保护特性实验研究

徐蕴婕，张 驰，钱 锐   

  1. 泛亚汽车技术中心有限公司
  • 出版日期:2021-08-30 发布日期:2021-08-30
  • 通讯作者: 徐蕴婕
  • 作者简介:徐蕴婕，空调工程高级经理，就职于泛亚汽车技术中心有限公司，主要从事空调及整车热管理开发。

Experimental Frosting Study under Protection Condition of Front Evaporator on New Energy Vehicle

SUI Guansheng1, ZHAO Bo1, YANG Changgeng2, JIA Yonghui3   

  1. Pan Asia Technical Automotive Center Co., Ltd.
  • Online:2021-08-30 Published:2021-08-30
  • Contact: XU Yunjie

PDF

摘要： 为了研究新能源车前端蒸发器结霜问题，搭建了结霜测试台架，引入通用的压缩机低压保护策略，研究了 前端蒸发器结霜情况。结果表明：系统出风温度和系统制热量随着霜层发展持续下降，最大损失达到了 48.7%，因 此系统必须通过其他方式补全损失的制热能力，系统效率（COP）在进入低压保护后会上升。通过 PTC 补足结霜 制热能力损失时，系统总效率从 2.2 降低至 1.4，推荐行车时使用 PTC 补全由结霜带来的制热能力损失。

关键词: 新能源车；前端蒸发器；结霜

Abstract: To study the frosting problem of the front evaporator of new energy vehicles, a frosting test bench has been built. Considering the general low-pressure protection strategy of compressor, the frosting of front evaporator has been studied. The results show that the outlet air temperature and heating capacity of the system decrease continuously with the development of frost layer, and the maximum loss reaches 48.7%. Therefore, the system must compensate the lost heating capacity by other ways. The COP of the system will rise after entering the low-pressure protection. By using PTC to compensate the loss of frosting heating capacity, the total efficiency of the system decreases from 2.2 to 1.4. It is recommended to use PTC under the driving condition to compensate the loss of heating capacity caused by frosting.

Key words: New energy vehicle; Front evaporator; Frosting