主办：陕西省汽车工程学会
ISSN 1671-7988  CN 61-1394/TH
创刊：1976年
汽车实用技术

汽车实用技术 ›› 2024, Vol. 49 ›› Issue (20): 53-57.DOI: 10.16638/j.cnki.1671-7988.2024.020.010

• 设计研究 • 上一篇    

一种高压蓄能液压助力制动系统在商用车上的应用

周长辉，刘小云，余金霞   

  1. 江铃汽车股份有限公司
  • 发布日期:2024-10-21
  • 通讯作者: 周长辉
  • 作者简介:周长辉（1986－），男，工程师，研究方向为汽车底盘电控开发，E-mail:czhou12@jmc.com.cn

Application of a High Pressure Storage Hydraulic Power Braking System in Commercial Vehicles

ZHOU Changhui, LIU Xiaoyun, YU Jinxia   

  1. Jiangling Motors Corporation Limited
  • Published:2024-10-21
  • Contact: ZHOU Changhui

PDF

摘要： 为了摆脱车辆对真空源及真空度、气压等的限制，文章提出一种采用高压蓄能液压助 力制动系统代替传统真空助力器；然后通过采用高压蓄能液压助力制动系统在某商用轻卡车 辆进行制动选型的理论计算校核，替代原车真空助力器进行实车改制、调试匹配；最后进行 制动性能对比测试。结果表明，该系统在制动性能及踏板感上均优于真空助力器，支持 4.5 t 以上大吨位载重，通过该方案的理论分析与实车改制测试，结果符合预期，具备一定的工程 应用价值。

关键词: 液压制动系统；高压蓄能器；商用轻卡；真空助力器；制动选型

Abstract: In order to get rid of the restrictions of vacuum source, vacuum degree and air pressure, this paper proposes a high pressure storage hydraulic power brake system instead of the traditional vacuum booster. Then through the theoretical calculation and verification of the high pressure storage hydraulic power brake system for brake selection in a commercial light truck vehicle, replacing the original vacuum booster for real vehicle restructuring, debugging and matching. Finally, the braking performance is tested. The results show that the system is superior to the vacuum booster in braking performance and pedal feeling, and supports large tonnage load above 4.5 t. Through theoretical analysis and real vehicle restructuring test, the results are in line with expectations and have certain engineering application value.

Key words: hydraulic braking system; high pressure storage; commercial light truck; vacuum booster; braking selection